menu menu_open
Brasil
home Sumário navigate_before Anterior Atual Seguinte navigate_next
home Sumário
CROP PRODUCTION • Cienc. Rural 50 (7) • 2020 • https://doi.org/10.1590/0103-8478cr20200109 linkcopy

Open-access Yield increase of corn inoculated with a commercial arbuscular mycorrhizal inoculant in Brazil

Rendimento de grãos da cultura do milho com inoculante micorrízico arbuscular comercial no Brasil

AuthorshipSCIMAGO INSTITUTIONS RANKINGS

    ABSTRACT:

    Arbuscular mycorrhizal fungi (AMF) play an important role in plant growth. However, there are no reports of legally commercialized AMF-based inoculants for agricultural crops in Brazil. The objective of this research was to evaluate the agronomic efficiency of a Rhizophagus intraradices inoculant in combination with phosphate fertilization in grain yield of corn under different edaphoclimatic conditions in Brazil. Experiments were conducted in five Brazilian states (Goiás, Mato Grosso, Minas Gerais, Rio Grande do Sul and Santa Catarina) in a 2 x 3 factorial scheme, with two inoculation treatments (inoculated and non-inoculated seeds) and three doses of phosphate fertilization (0, 50 and 100% of the recommended P). At the end of the crop cycle (stages R4-R5), inoculation provided increases in biomass (average of 48%) regardless of the applied dose of P, higher P absorption, and 54% average increase in grain yield. In conclusion, the mycorrhizal inoculant increases biomass yield, P uptake and corn grain yield under different edaphoclimatic conditions in Brazil, especially in soils that originally had low or medium levels of available P.

    Key words: Rhizophagus intraradices; arbuscular mycorrhizae; phosphate fertilization; seed inoculant.

    RESUMO:

    Os fungos micorrízicos arbusculares (FMA) desempenham um papel importante no crescimento das plantas, no entanto, não há relatos de inoculantes legais baseados em AMF para culturas agrícolas no Brasil. O objetivo deste trabalho foi avaliar a eficiência agronômica de um inoculante a base de Rhizophagus intraradices em combinação com a adubação fosfatada no rendimento de grãos de milho sob diferentes condições edafoclimáticas no Brasil. Os experimentos foram conduzidos em cinco estados brasileiros (Goiás, Mato Grosso, Minas Gerais, Rio Grande do Sul e Santa Catarina) em esquema fatorial 2 x 3, com dois tratamentos de inoculação (sementes inoculadas e não inoculadas) e três doses de adubação fosfatada (0, 50 e 100% do P recomendado). No final do ciclo da cultura (estágios R4-R5), a inoculação proporcionou aumentos na biomassa (média de 48%), independentemente da dose aplicada de P, maior absorção de P e aumento médio de 54% no rendimento de grãos. Conclui-se que o inoculante micorrízico arbuscular aumenta a produção de biomassa, a absorção de P e a produtividade de grãos de milho em diferentes condições edafoclimáticas no Brasil, especialmente em solos que originalmente apresentavam níveis baixos ou médios de P.

    Palavras-chave: Rhizophagus intraradices; micorriza arbuscular; adubação fosfatada; inoculação de sementes

    INTRODUCTION:

    Arbuscular mycorrhizae represent a symbiotic relationship between arbuscular mycorrhizal fungi (AMF) and plant roots of various species with attested benefits for plant growth (SMITH & READ, 2008). The AMF are obligatory biotrophic microorganisms, as they require association with plant roots to complete their life cycle. In this relationship, the AMF transfer water and nutrients from the soil to the plant, while the plant provides photoassimilates to the fungi (BI et al., 2005). The AMF hyphal network penetrates the roots and spreads into the soil, becoming an extension of the root system, increasing the volume and nutrient absorption efficiency of the soil (SMITH & READ, 2008).

    The AMF provide a number of benefits to surrounding plants and the environment (BERRUTI et al., 2015). Among the direct benefits, the best known is the largest nutrient uptake, notably phosphorus (P), due to the low mobility of this nutrient in the soil (SMITH & READ, 2008). In addition to the higher P contribution, it is recognized that AMF can contribute to plant growth through other mechanisms, such as greater tolerance to water deficit (GARG & CHANDEL, 2010), nutrient supply (SHARIF et al., 2011; HART & FORSYTHE, 2012; DANIA et al., 2013), root protection against pathogen attack (JUNG et al., 2012), soil organic matter (SOM) accumulation through the formation and aggregation of soil (RILLING et al., 2002; RILLIG, 2004), and stimulation of the metabolic activity of other microorganisms (RILLIG & MUMMEY, 2006).

    While AMF have effects on plant growth and nutrition, physical, chemical and biological characteristics of the soil also influence the establishment of the symbiosis. Several researchers have explored the effect of different soil P concentrations on the potential of AMF (SMITH et al., 2011; CELY et al., 2016) and showed the existence of signaling occurring between plants and different AMF species, which vary according to soil characteristics.

    Currently, more than 300 species of AMF are described (SCHÜΒLER & WALKER, 2019). Rhizophagus intraradices (NC Schenck & GS Sm.) C. Walker and A. Schüßler (until recently classified as Glomus intraradices) is a generalist AMF species, and the list of plants that benefits by the association with R. intraradices includes important crops such as corn (GUO et al., 2014), soybeans (SPAGNOLETTI & LAVADO, 2015), beans (TAJINI et al., 2012), wheat (ARDAKANI et al., 2011) and cotton (ORAK & DEMIR, 2011).

    Despite the potential of AMF for the application in agriculture, the production process bumps into its obligatory symbiotic character, which makes it difficult to produce large volumes of propagules in a short period, an essential feature to enable the application in annual crops that represent large areas of agricultural production such as maize. Traditional models of multiplication of AMF are based on the use of trap plants or plant tissue culture (VOSÁTKA et al., 2012; BERRUTI et al., 2015), but there are still few reports in the literature about an efficient production process that would be able to supply the Brazilian agricultural market with arbuscular mycorrhizal inoculants. Therefore, evaluating the agronomic efficiency of inoculants based on FMA in different edaphoclimatic conditions and management systems is important, since the chemical, physical and biological conditions of the soil influence the life cycle of AMF and the symbiotic establishment of plants of interest in agricultural production (SMITH & READ, 2008).

    The technical and scientific community and farmers have shown interest in sustainable practices. In that respect, studies to introduce, maintain, and increase AMF populations in production systems, seeking to ensure higher yields for more sustainable agricultural production are required to prove the effects of AMF inoculants.

    Thus, the objective of this research was to evaluate the field agronomic efficiency of a commercial AMF-inoculant containing propagules of R. intraradices, in combination to different phosphate fertilization levels, in the growth and yield of corn in five different edaphoclimatic locations in Brazil.

    MATERIALS AND METHODS:

    Experiments were carried out in the field to validate the efficiency and viability of the AMF-based inoculant, following the protocols imposed by MAPA (Ministry of Agriculture, Livestock and Supply) for product registration of plant growth promoting microorganisms, following the IN SDA 13 from 03/25/2011 (BRASIL, 2011) and IN SDA 53, from 10/24/2013 (BRASIL, 2013). Among the main requirements for the registration of microbial inoculants, there is the need to demonstrate the agronomic efficiency of the product in at least four locations of the country with distinct edaphoclimatic conditions.

    Experiments were conducted in the 2016/2017 crop cycle (September 2016 to March 2017), considering the planting dates, cultivars and agricultural driving practices of each tested location. For this, five representative locations with distinct edaphoclimatic characteristics were selected (Table 1).

    Thumbnail
    Table 1
    Information on sowing, harvesting, cultivar, soil characteristics, chemicals and agronomic practices employed in each location.

    All fertilization procedures (based on soil analysis and expected corn yield) (SBCS, 2004), and crop treatment followed the recommendations for each location. The experiments were conducted until the plants completed the grain pre-maturation cycle. Harvest was done when corn grains were in the kernel dough to kernel dent stages (R4-R5), that is, the phase immediately before physiological maturation (MAGALHÃES & DURÃES, 2006).

    In the municipality of Xanxerê (SC), the experiment was implemented in randomized blocks, since sowing was manual. In the other locations, where sowing was mechanized, the experiments were implemented in split plots. In all cases the experiments followed a 2 x 3 factorial scheme (inoculated and non-inoculated seeds in the plots), with three phosphate fertilization treatments (no fertilization, 50%, and 100% of the recommended P) in 6 replications.

    The experimental plots (36 plots per location) were assembled with an area of 24 m2 (4 m x 6 m), occupying a total area of 1,333 m2 (already considering 1 meter spacing between plots). The working area of each plot consisted of the central 10 m2 portion of each plot (6 lines spaced by 0.5 m x 4 linear meters).

    The tested product, under the trade name of Rootella BR (registered under No. 22902 10000-0), is obtained through a hybrid system of fungal propagule production using trap plants (BERRUTI et al., 2015) and tissue culture (DIOP, 2003; SRINIVASAN et al., 2014; SCHUESSLER, 2015), and the production process employed in the formulation cannot be presented because it is under industrial secrecy.

    The product was characterized and its purity certified. The number of propagules, the exclusive presence of propagules of R. intraradices and the strain ID was also determined in this study in the laboratory of microorganisms and biotechnological processes at UFSC. The identification approach considered characteristics inherent to fungal spores, such as number, thickness, coloration, and ornamentation of the layers that cover the spore (https://invam.wvu.edu/). For the inoculant quantification, the Most Probable Number (MPN) method (OBLINGER & KOBURGER, 1975) was adopted to prove the concentration of 2,500 propagules per gram of product (Rootella BR), as indicated in the product label.

    Seeds were inoculated with the initial addition of a liquid adhesive (Symbiosis Pró) and subsequent incorporation of the inoculant at the time of sowing following the adhesive manufacturer’s recommendation (Líder Agronegócios). The recommended amount of inoculant tested in the study (Rootella BR) was 1 kg ha-1, regardless of plant stand used, which assured a concentration of 2,500,000 propagules ha-1, a quantity confirmed by the MPN assays. The inoculant tested contains a mixed composition of spores and other fungal propagules (hyphae), and is formulated using sterile ultrafine vermiculite as inert vehicle. The non-inoculated treatment consisted of sowing the seeds using only the inert vehicle. For the inoculated treatments, seeds were homogenized with the mycorrhizal inoculant with the aid of plastic containers previously disinfected.

    Crop management adopted in each location is described in table 2. For two of the evaluated states (RS and SC), seeds were treated with specific fungicides before planting. In addition to seed treatment, fungicides were also used during the crop cycle in the state of RS. The choice of products was based on the fungal disease identified in each evaluated location. Weed and insect control were carried out using specific herbicides and insecticides for each situation, respectively.

    Thumbnail
    Table 2
    Edaphoclimatic characteristics and fungicides applied in each location.

    In compliance with the minimum requirements established by IN SDA 13 from 03/25/2011 (BRASIL, 2011) and IN SDA 53, from 10/24/2013 (BRASIL, 2013), dry biomass of shoots, grain yield, P content and accumulation in the shoot biomass were evaluated. For that purpose, 30 plants were collected at the R4-R5 phenological stages from the four central lines of each plot (10 m2 working area). The biomass was dried in a forced air circulation oven at 60 °C until weight stabilization. Grain yield was determined from the grain yield of the working area of each plot, based on the yield obtained for the 30 plants evaluated per plot.

    The contents and accumulation of P were determined from a sample composed of 10 leaves collected in different portions of plants randomly selected in the working area of each plot following the method described by TEDESCO et al. (1995). The leaf closest to the last ear was collected at the time of the appearance of female inflorescences. Two-way analysis of variance was performed and the separation of means obtained by Tukey’s test at 5% probability using the software SISVAR v.5.3.

    RESULTS AND DISCUSSION:

    In this experiment, the mycorrhizal inoculant significantly increased corn biomass in all sampled locations regardless of P rates applied (Table 3), confirming that proposed by CAVALCANTE et al. (2009) that corn is a species with high responsiveness to the inoculation of arbuscular mycorrhizal fungi. There was an average increase of 48% in biomass in the inoculated plants compared to the non-inoculated, with an amplitude of 13 to 122%. In most places, corn biomass increase in the low and medium P inoculated treatment-locations was equal to or higher than the non-inoculated treatment with the recommended dose of P.

    Thumbnail
    Table 3
    Effect of mycorrhizal inoculant application and phosphate fertilization on the dry biomass of corn (Mg ha-1).

    As observed in the present study, CELEBI et al. (2010) demonstrated the positive effect of AMF for the growth of maize, with an average increase of 31% in dry biomass for the AMF-inoculated maize varieties. SHARIF et al. (2011) verified average increases of 14% in shoot biomass, while KHALIL et al. (1994) demonstrated up to 400% increases in growth for the AMF-inoculated maize varieties. These results demonstrate the effects that AMF exert on plants, such as higher absorption of N (up to 75%) and P (up to 80%).

    There is well-documented evidence that AMF contribute to increase the availability and uptake of P, N and micronutrients (KRISHNA & BAGYARAJ, 1991; SMITH & READ, 2008). The mycorrhizal symbiosis, by linking the biotic and geochemical portions of the ecosystem, can be regarded as the bridge between roots and the surrounding soil microhabitats, allowing for the partition of soil nutrients, including N and P, in the ecosystems (TORO et al., 1997).

    Arbuscular mycorrhizal symbiosis is a widespread phenomenon and there is evidence of direct effects of mycorrhizal fungi on inorganic N metabolism and on N acquisition and assimilation by symbiotic systems (AZCÓN et al., 1982; TOBAR et al., 1994a, 1994b; ATUL-NAYYAR et al., 2009). Mycorrhizal status may alter the number and activity of N-transforming microorganisms, since changes in the soil environment are expected to affect microbial groups present in the soil.

    As for N, there are several studies that show the importance of AMF on the availability and distribution of P within plants in different ecosystems (SMITH & READ, 2008; SMITH & SMITH, 2011; WALDER & VAN DER HEIJDEN, 2015). These studies clearly establish that AMF mediate the phosphate uptake of plants and, in many cases, improve nutrition and productivity (BUCHER, 2007). Phosphate primarily uptake is mediated by the AMF arbuscules through the expression of host phosphate transporter genes (PUMPLIN et al., 2012), and high phosphate conditions significantly decrease the level of AMF colonization (BAYLIS, 1967; MOSSE, 1973; NAGY et al., 2009; BREUILLIN et al., 2010; BALZERGUE et al., 2011). It is even hypothesized that defense mechanisms participate in limiting AMF colonization in plants cultivated in phosphorus-sufficient conditions (LEHNERT et al., 2017). A recent study has shown that the supply of exogenous phosphate leads to a rapid (<5 h) suppression in arbuscule development and temporarily inhibits the growth of intraradical colonization (KOBAE et al., 2016).

    The literature also showed that different results of AMF may be obtained in different management conditions. For instance, areas with high levels of soil organic matter (SOM) may benefit from AMF by altering the levels of nutrient metabolism and assimilation (AZCÓN et al., 1982; TOBAR et al., 1994a, b; ATUL-NAYYAR et al., 2009). It is also known that other practices and variables have direct effects on the performance of AMF in agricultural systems. Among them, variations in soil type, indigenous AMF community and diversity, environmental changes, crop species and cultivars, and cultivation management (VAN GEEL, 2016; HART et al., 2017; JACOBY et al., 2017; SAWERS et al., 2017; KOBAE, 2019).

    Leaf P content ranged from 0.8 (Ritápolis - MG) to 2.8 g kg-1 (Cachoeira do Sul - RS) (Table 4), and positive effects of the inoculation were observed in the treatments with 0% P in three locations, and with 100% P in the municipality of Xanxerê (SC). The P content in the leaves may vary depending on factors such as light, temperature, soil texture, pest and disease attack (SMITH & READ, 2008), not depending solely on P supply. Therefore, the benefits of phosphate fertilization and AMF inoculation can be better observed and discussed by aggregating factors such as increments in biomass (Table 3), accumulation of P (Table 4) and grain yield (Figure 1).

    Thumbnail
    Table 4
    Effect of mycorrhizal inoculant application and phosphate fertilization on corn leaf.

    Figure 1
    Effect of mycorrhizal inoculant application and phosphate fertilization on grain yield of corn (Mg ha-1). * Significant effect of inoculation at 5% probability by F test within P doses; ns = non-significant effect of inoculation. Vertical bars represent the standard error. Averages followed by the same letter within the same inoculation treatment do not differ by Tukey’s test at 5% probability.

    The accumulation of P, determined based on P content as a function of the biomass yield, increased with the AMF inoculation (Table 4). Except for the area of Cachoeira do Sul (RS) in the treatment with 50% P (location that originally had high soil available P), the positive effect of the inoculation can be observed in all treatments, where the plants inoculated presented, on average, 80% increase of P accumulation in relation to the non-inoculated plants (Table 4). Increments ranged from 0 to 266% for the inoculated treatments, being considered significant increases equal to or greater than 26%.

    Grain yield presented significant increases in all locations where there was no phosphorus application, in four locations where 50% P was applied (Tangará da Serra - MT, Padre Bernardo - GO, Xanxerê - SC, e Ritápois - MG), and in three locations where 100% of the recommended P was applied (Tangará da Serra - MT, Padre Bernardo - GO, and Ritápois - MG.)(Figure 1). Grain yield for the inoculated over the non-inoculated plants was 54% (on average) higher, ranging from 11 to 138%. In treatments where grain yield of the inoculated plants was equal to or higher than the control (100% P and not inoculated), the increases were up to 80% (Tangará da Serra-MT). Inoculated plants with 0% P in the experimental area of Ritápolis (MG) did not reach the control average (100% P and not inoculated), but presented a 90% higher grain yield when compared to the non-inoculated plants of the same dose of P. Regarding the effect of inoculation on grain yield among the different levels of available P, the largest increments were observed in the locations with the lowest P availability. In the municipality of Cachoeira do Sul (RS), the highest soil P available of them all, inoculation responses were less expressive, and at doses of 50 and 100% P, the inoculation did not provide significant increases in grain yield (Figure 1). Although, not providing significant increases in yield for the doses of 50 and 100% P, inoculation in the 0% P in RS increased grain yield by 30%, equaling the control treatment of that location (100% P and not inoculated).

    The 50% P inoculated treatments presented, on average, grain yields 1,490 kg ha-1greater than the non-inoculated 100% P treatment (7,100 kg ha-1 vs. 5,610 kg ha-1, average of all locations). This represents a direct net gain of U$ 226.48 ha-1 (current market values). If we add to that the reduction in fertilizer application (100% P to 50% P), there is an additional gain of U$ 77.10 ha-1, bringing the total net gain to U$ 303.58 ha-1. In an overall estimation, the 50% P inoculated treatments, presented, according to the study, an average (current market prices) of 35% greater economic income (net gain) than the 100% P non-inoculated treatments.

    As seen previously in the aforementioned works, such as that of DANIA et al. (2013), inoculation with AMF promoted increases of up to 32% in corn grain yield. In the present study, the inoculant promoted even higher increments, reaching an average of 54% increment (local average, regardless of phosphate fertilization level). These results showed that the addition of the inoculant, especially in soils with low or medium available P, results in significant gains in grain yield for corn under different edaphoclimatic conditions.

    CONCLUSION:

    The mycorrhizal inoculant Rootella BR based on R. intraradices increases the biomass yield and P uptake by corn. Inoculation with this fungus increases the yield of corn under different edaphoclimatic conditions in Brazil, especially in soils that originally had low or medium levels of available soil P.

    ACKNOWLEDGEMENTS

    This study was financed in part by the Coordenação de Aperfeiçoamento de Pessoal de Nível Superior - Brasil (CAPES) - Finance Code 001.

    REFERENCES

    • CR-2020-0109.R1

    Publication Dates

    • Publication in this collection
      08 June 2020
    • Date of issue
      2020

    History

    • Received
      06 Feb 2020
    • Accepted
      02 Apr 2020
    • Reviewed
      18 May 2020
    Creative Common - by 4.0
    This is an open-access article distributed under the terms of the Creative Commons Attribution License
    vertical_align_top file_download show_chart
    location_on
    Universidade Federal de Santa Maria Universidade Federal de Santa Maria, Centro de Ciências Rurais , 97105-900 Santa Maria RS Brazil , Tel.: +55 55 3220-8698 , Fax: +55 55 3220-8695 - Santa Maria - RS - Brazil
    E-mail: cienciarural@mail.ufsm.br
    rss_feed Acompanhe os números deste periódico no seu leitor de RSS
    Acessibilidade / Reportar erro