Evaluation of sorghum straw hemicellulosic hydrolysate for biotechnological production of xylitol by Candida guilliermondii

INDUSTRIAL MICROBIOLOGY

Evaluation of sorghum straw hemicellulosic hydrolysate for biotechnological production of xylitol by Candida guilliermondii

L. Sene^I,*; P.V. Arruda^II; S.M.M. Oliveira^I; M.G.A. Felipe^II

^IUniversidade Estadual do Oeste do Paraná, Cascavel, PR, Brasil

^IIEscola de Engenharia de Lorena, Universidade de São Paulo, Lorena, SP, Brasil

ABSTRACT

A preliminary study on xylitol production by Candida guilliermondii in sorghum straw hemicellulosic hydrolysate was performed. Hydrolysate had high xylose content and inhibitors concentrations did not exceed the commonly found values in other hemicellulosic hydrolysates. The highest xylitol yield (0.44 g/g) and productivity (0.19 g/Lh) were verified after 72 hours.

Key words: sorghum straw, hemicellulosic hydrolysate, xylose, xylitol, Candida guilliermondii.

Xylitol is a sweetener with important properties such as anticariogenicity and metabolism not insulin-dependent [7]. Xylitol is commercially produced from chemical catalysis of xylose, obtained from xylan-rich lignocellulosic materials [9]. Several xylose-xylitol fermenting microorganisms were identified, among which several species of yeasts were recognized as good xylitol producers, especially members of the genus Candida because of the high efficiencies obtained during the conversion of pure xylose and hemicellulosic hydrolysates [3]. The species Candida guilliermondii has been continuously evaluated for the xylitol production in hemicellulosic hydrolysates from different lignocellulosic materials [10, 16, 25].

Dilute acid hydrolysis is a method commonly used for solubilization of sugars present in hemicellulose. Studies have demonstrated that the biotechnological production of xylitol from lignocellulosic residues is influenced by the type of hemicellulosic hydrolysate, due mainly to the presence of different concentrations of toxic compounds released during the hydrolytic process: acetic acid, released by hemicellulose structure; two most common furaldehydes, HMF (5-hydroxymethyl-2-furaldehyde) and furfural (2-furaldehyde), formed at severe hydrolysis conditions from hexoses and pentoses, respectively, and phenolic compounds, formed during partial lignin breakdown [3]. These compounds inhibit microbial metabolism due to their concentrations in the medium [4,17].

Sorghum straw is a renewable and cheap resource, commonly used as livestock feed. However, it has scarcely been studied as raw material for biological processes. Major studies on biotechnological utilization of sorghum straw deals with furfural production [24], cellulase-free xylanase production in solid-state fermentation - SSF [22], ethanol production by simultaneous saccharification with commercial cellulase and fermentation (SFS) [1], ethanol production by SSF of untreated and treated (delignified) sorghum stover [13] and xylitol production by Candida parapsilosis [19]. Studies on the hydrolysis of hemicelullosic fraction of sorghum straw [6,23] show a possible alternative source of xylose to several biotechnological processes.

As the lignocellulosic materials are rather heterogeneous in terms of chemical composition, the objective of this study was to investigate the viability of using forage sorghum straw hemicellulosic hydrolysate for xylitol production by the yeast C. guilliermondii.

For inoculum preparation, the yeast Candida guilliermondii FTI 20037 was grown in 125 mL-Erlenmeyers flasks, containing 50 mL of medium formulated with xylose (30 g/L), rice bran extract (20 g/L), (NH₄)₂SO₄ (2 g/L) and CaCl₂.2H₂O (0.1 g/L) at pH 5.5 and incubated in a rotary shaker (200 rpm) at 30ºC for 24 hours. Then cells were separated by centrifugation at 2,900 g for 20 minutes, rinsed twice with sterile distilled water and resuspended in an adequate volume of distilled water. The initial cell concentration for the experiment was 1.0 g/L.

Forage sorghum straw was hydrolyzed in a 350 L AISI 316 stainless steel reactor at 121ºC during 10 minutes with 100 mg H₂SO₄/g sorghum straw (dry weight) in a solid:liquid ratio of 1:10. Thereafter, the hydrolysate was filtered and concentrated under vacuum at 70 ± 5ºC to increase xylose concentration threefold. In order to reduce the concentrations of toxic compounds, the hydrolysate was then treated by increasing the initial pH from 1.27 to 7.0 with CaO following its reduction to pH 2.5 with H₃PO₄ and subsequent treatment with active charcoal adsorption (1 % w/v) in Erlenmeyer flasks on a rotary shaker at 200 rpm, 60ºC, for 30 minutes. The resultant precipitates from all stages of the treatment were removed by vacuum filtration using qualitative filter paper [8].

Fermentation was carried out in triplicate, in 125 mL-Erlermeyer flasks containing 50 mL of hydrolysate, previously detoxified and autoclaved at 115ºC for 15 minutes, supplemented with the same nutrients used for inoculum preparation except for xylose, and pH adjusted by the addition of NaOH solution to pH 5.5. The flasks were left under agitation (200 rpm) at 30ºC for 72 hours.

The concentrations of D-xylose, D-glucose, L-arabinose, xylitol, ethanol and acetic acid were determined by high-performance liquid chromatography (Shimadzu LC-10AD) using a refractive index detector and a Bio-Rad Aminex HPX-87H column (300 x 7.8 mm) at 45 ºC, 0.01 N H₂SO₄ as an eluent at a 0.6mL/min-flow rate and an injection volume of 20 µL [15]. Furfural and 5-hydroxymethylfurfural were determined with a UV detector (SPD-10A UV-VIS) and a Hewllet-Packard RP18 column at 25ºC, acetonitrile/H₂O (1:8) plus 1% acetic acid as eluent, injection volume of 20 µL [15]. Phenolic compounds were estimated by UV-VIS spectrometry by the Folin-Ciocalteau method [21]. Cell concentrations were monitored by following absorbance readings (600 nm) of 3 mL samples which were correlated with dry cell mass (g/L) using a standard curve.

The partial characterization of sorghum straw hemicellulosic hydrolysate, obtained after diluted acid hydrolysis with H₂SO₄, showed a high xylose content (17.69 g/L) regarding other sugars (glucose 2.1 g/L and arabinose 1.81 g/L), and a low glucose:xylose ratio (1:8). Although repression of xylose utilization by glucose is well known in yeasts, similar glucose:xylose ratios improved xylitol production in C. guilliermondii [20].

Concerning the presence of toxic compounds released during the acid hydrolysis of sorghum straw, it can be observed that acetic acid (1.87 g/L) and phenols (2.12 g/L) are the main inhibitors, but their content as well as furfural (0.04 g/L), 5-HMF (1.56 g/L) and metal concentrations (Ni 0.009 g/L, Cr 0.017 g/L, Zn 0.007 g/L, Fe 0.022 g/L and Ca 0.2 g/L) do not exceed the range found in other hemicellulosic hydrolysates [2, 8, 11, 25] as well as in sorghum straw hydrolysates [6, 19, 23] obtained under different conditions.

Detoxified threefold concentrated hydrolysate presented the following composition (g/L): glucose 4.30 g/L; xylose 43.78 g/L; arabinose 4.32 g/L; acetic acid 3.13 g/L; furfural 0.05 g/L; 5-HMF 1.52 g/L and total phenols 1.36 g/L. When compared to the untreated hydrolysate (data not shown), moderate removals of phenolic compounds (67 %) and acetic acid (31 %) were obtained with the detoxification process employed, i.e., overliming combined with activated charcoal. Previous reports have shown that overliming and activated charcoal treatment did not largely affect acetic acid concentration [12,25], whereas activated charcoal was efficient for the reduction of furan derivatives in different types of hemicellulosic hydrolysates [8,25]. However, the results of several researches have shown that treatment with active charcoal was dependent on variables as temperature, contact time, hydrolysate:charcoal ratio and pH with a significant effect on detoxification of sugarcane bagasse hydrolysate [8], rice straw hydrolysate [10] and in sorghum straw hydrolysate [19]. Phenolic compounds are shown to be the major inhibitors in lignocellulosic hydrolysates [12] and can be more easily removed with anion-exchange resin treatments [2,25], although these are onerous processes. Overliming and activated charcoal adsorption are the most economical treatments for hydrolysates. Moreover, the precipitates containing calcium ions formed during overliming may be used to correct soil acidity without environmental damage.

The experimental results of batch fermentation of sorghum straw hemicellulosic hydrolystate by C. guilliermondii are shown in Figures 1A and B. According to Figure 1A, glucose was not detected in the medium after 6 hours. Repression of xylose utilization by glucose was not observed and probably occurred before this period. Xylose was consumed at a rate of 19-26% up to 48 hours (calculated as instantaneous, i.e., in 12-hour intervals), which increased to 36-37% afterwards. The biomass concentration profile shows a faster growth up to 6 hours, which coincided with glucose depletion. After this period, specific growth rate (µ_X) decreased from 0.119 h^-1 to 0.013 h^-1. Although xylose consumption was observed after 6 hours, xylitol formation initialized only after 24 hours, which indicates that xylose utilization during the first 24 hours was directed to growth. These results are in agreement with previous studies which support that xylitol production is not-growth-related, but a consequence of redox inbalance [5].

 

Ethanol formation was faster in the first 24 hours of fermentation (Figure 1B), probably due to the presence of glucose and the poor contribution of xylose and arabinose to its formation. After 24 hours, ethanol production was negligible and reached a maximum of 2.8 g/L. Ethanol, a byproduct of xylose-xylitol conversion, was also found during the growth of C. guilliermondii in semidefined medium [5] and sugarcane hemicellulosic hydrolysate [16] and its formation was dependent on the medium pH [14].

Figure 1B shows the acetic acid concentration throughout the fermentation. This acid was slowly and concurrently assimilated with xylose, resulting in a slight increase in pH values. Almost 28% of acetic acid was assimilated within up to 72 hours. Despite toxicity of acetic acid to yeast metabolism, its consumption was previously observed in experiments with C. guilliermondii and the toxicity degree was related to several environmental factors, mainly its concentration in the culture medium. When present in low concentration (1 g/L) in the medium, acetic acid can increase xylitol production by C. guilliermondii [4] and the higher the degree of cell adaptation, the higher the capacity of C. guilliermondii cells to metabolize acetic acid [18], resulting in significant increases in fermentative parameters.

Table 1 summarizes fermentative parameters of C. guilliermondii grown in sorghum straw hydrolysate. The highest xylitol yield (0.44 g/g), corresponding to 48% of the theoretical based on xylose, and the highest productivity (0.19 g/Lh) were obtained after 72 hours of fermentation, although yields up to 75-97% have often been reported with this yeast in other hemicellulosic hydrolysates [10, 16, 18, 25]. In the present assay, 6.9 g/L of xylose still remained in the medium. If the cultivation time was prolonged, the final amount of xylitol estimated would be 16.6 g/L, considering the same xylitol yield verified at 72 hours and still adequate nutritional conditions.

The possibility of using detoxified sorghum straw hydrolysates for xylitol production was confirmed in fermentation with C. parapsilosis, in which a maximal xylitol concentration of 17 g/L, a product yield of 0.27 g/g and a productivity of 0.12 g/Lh were obtained. These values were higher than those obtained with that yeast in synthetic media [19]. In the present study, C. guilliermondii did not show appreciable fermentative performance when compared to previous results with such yeast in synthetic media and in other hemicellulosic hydrolysates. This is probably due to interactive effects of inhibitory compounds. It is worth noting that little is currently known regarding the effect of metals ions in the culture medium, the maximum allowed concentration for each one as well as the simultaneous presence of several other inhibitors on xylose metabolism. Further studies are necessary to establish an adequate acid hydrolysis and an adequate process of detoxification of sorghum straw hemicellulosic hydrolysate aiming at achieving an efficient conversion of xylose to xylitol with C. guilliermondii. Additionally, considering that hemicellulosic fraction is easily extracted from biomass and that pentoses can be co-fermented to ethanol by genetically engineered yeasts, the efforts of recovering xylose from sorghum straw as well as an economical hydrolysis of cellulose can offer a potential approach to ethanol production.

Submitted: May 13, 2010; Returned to authors for corrections: December 22, 2010; Approved: May 16, 2011.

• 1. Ballesteros, M; Oliva, J.M.; Negro, M.J.; Manzanares, P.; Ballesteros, I. (2004). Ethanol from lignocellulosic materials by a simultaneous saccharification and fermentation process (SFS) with Kluyveromyces marxianus CECT 10875. Process Biochem 39(12),1843-1848.
• 2. Carvalheiro, F.; Duarte, L.C.; Lopes, S.; Parajó, J.C.; Pereira, H.; Gírio, F.M. (2005). Evaluation of the detoxification of brewery's spent grain hydrolysate for xylitol production by Debaryomyces hansenii CCMI 941. Process Biochem 40(3),1215-1223.
• 3. Felipe, M.G.A. (2004). Biotechnological production of xylitol from lignocellulosic materials. In: Saha, B.C.; Hayashi, K. (eds). Lignocellulose biodegradation, vol. 889. American Chemical Society, Washington, D.C., USA, p.300-315.
• 4. Felipe, M.G.A.; Vieira, D.C.; Vitolo, M.; Silva, S.S.; Roberto, I.C.; Mancilha, I.M. (1995). Effect of acetic acid on xylose fermentation to xylitol by Candida guilliermondii. J. Basic Microbiol 35(3),171-177.
• 5. Granström, T.; Ojamo, H., Leisola, M. (2001) Chemostat study of xylitol production by Candida guilliermondii. Appl. Microbiol. Biotechnol 55(1),36-42.
• 6. Herrera, A.; Téllez-Luis, S.J.; González-Cabriales, J.J.; Ramírez, J.A.; Vázquez, M. (2004). Effect of the hydrochloric acid concentration on the hydrolysis of sorghum straw at atmospheric pressure. J. Food Eng. 63(1),103-109.
• 7. Manz, U.; Vanninen, E.; Voirol, F. (1973). Xylitol - its properties and use as a sugar substitute in foods. Food R. A. Symp. Sugar and Sugar Replacements, London, UK.
• 8. Marton, J.M.; Felipe, M.G.A.; Silva, J.B.A.; Pessoa Junior, A. (2006). Evaluation of the activated charcoals and adsorption conditions used in the treatment of sugarcane bagasse hydrolysate for xylitol production. Braz. J. Chem. Eng 23(1),9-21.
• 9. Melaja, J.; Hämälainen, L. February 1977. Process for making xylitol. US. Pat. 4,008,285.
• 10. Mussatto, S.I.; Roberto, I.C. (2001). Hydrolysate detoxification with activated charcoal for xylitol production by Candida guilliermondii. Biotechnol. Lett 23(20),1681-1684.
• 11. Mussato, S.I.; Roberto, I.C. (2004). Optimal experimental conditions for hemicellulosic hydrolyzate treatment with activated charcoal for xylitol production. Biotechnol. Progress 20(1),134-139.
• 12. Palmqvist, E.; Hahn-Hägerdal, B. (2000). Fermentation of lignocellulosic hydrolysates. I: inhibition and detoxification. Biores. Technol 74(1),17-24.
• 13. Rani, K.S.; Swamy, M.V.; Seenayya, G. (1998). Production of ethanol from various pure and natural cellulosic biomass by Clostridium thermocellum strains SS21 and SS22. Process. Biochem. 33(4),435-440.
• 14. Roberto, I.C.; Silva, S.S.; Felipe, M.G.A.; Mancilha, I.M.; Sato, S. (1996). Bioconversion of rice straw hemicellulose hydrolysate for the production of xylitol: effect of pH and nitrogen source. Appl. Biochem. Biotechnol 57-58(1),339-347.
• 15. Rodrigues, R.C.L.B.; Felipe, M.G.A.; Silva, J.B.A.; Vitolo, M.; Gómez P.V. (2001). The influence of pH, temperature and hydrolysate concentration on the removal of volatile and non-volatile compounds from sugarcane bagasse hydrolysate treated with activated charcoal before or after vacuum evaporation. Braz. J. Chem. Eng 18(3),299-311.
• 16. Rodrigues, R.C.L.B.; Sene, L.; Gilvane, S.M.; Roberto, I.C.; Pessoa Jr., A.; Felipe, M.G.A. (2006). Enhanced xylitol production by precultivation of Candida guilliermondii cells in sugarcane bagasse hemicellulosic hydrolysate. Curr. Microbiol. 53(1),53-59.
• 17. Sanches, B.; Bautista, J. (1998). Effects of furfural and 5-hydroxymethylfurfural on the fermentation of Saccharomyces cerevisiae and biomass production from Candida guilliermondii. Enzyme Microb. Technol. 10(5),315-318.
• 18. Sene, L.; Felipe, M.G.A.; Vitolo, M.; Silva, S.S.; Mancilha, I.M. (1998). Adaptation and reutilization of Candida guilliermondii cells for xylitol production in bagasse hydrolysate. J. Basic Microbiol 38(1),61-69 .
• 19. Sepúlveda-Huerta, E.; Tellez-Luis, S.J.; Bocanegra-García, V.; Ramírez, J.A.; Vázquez, M. (2006). Production of detoxified sorghum straw hydrolysates for fermentative purposes. J. Sci. Food. Agric. 86(15),2579-2586.
• 20. Silva, D.D.V.; Felipe, M.G.A. (2006). Effect of glucose:xylose ratio on xylose reductase and xylitol dehydrogenase activities from Candida guilliermondii in sugarcane bagasse hydrolysate. J. Chem. Technol. Biotechnol 81(7),1294-1300.
• 21. Singleton, V.L.; Orthofer, R.; Lamuela-Raventós, R.M. (1999). Analysis of total phenols and other oxidation substrates and antioxidants by means of Folin-Ciocalteau reagent. In: Packer, L. (ed.) Methods in Enzymology, vol. 299: Academic Press, New York, USA, p.152-178.
• 22. Sonia, K.G.; Chadha, B.S.; Saini, H.S. (2005). Sorghum straw for xylanase hyper-production by Thermomyces lanuginosus (D₂W₃) under solid-state fermentation. Biores. Technol 96(14),1561-1569.
• 23. Téllez-Luis, S.J.; Ramírez, J.A.; Vázquez, M. (2002). Mathematical modelling of hemicellulosic sugar production from sorghum straw. J. Food Eng 52(3),285-291.
• 24. Vázquez, M.; Oliva, M.; Téllez-Luis, S.J.; Ramírez, J.A. (2007). Hydrolysis of sorghum straw using phosphoric acid: Evaluation of furfural production. Biores. Technol 98(16),3053-3060.
• 25. Villarreal, M.L.M.; Prata, A.M.R.; Felipe, M.G.A.; Almeida e Silva, J.B. (2006). Detoxification procedures of Eucalyptus hemicellulose hydrolysate for xylitol production by Candida guilliermondii. Enzyme Microb. Technol 40(1),17-24.

Publication Dates

• Publication in this collection
  21 Dec 2011
• Date of issue
  Sept 2011

History

• Accepted
  16 Mar 2011
• Reviewed
  22 Dec 2010
• Received
  13 Mar 2010